Making Tortillas (Fresh Masa)

By Lesley Téllez | October 02, 2015


  • 1 1/2 cups masa harina or 1 pound tortilla masa ground from fresh nixtamal (see below)
  • 1 cup plus 2 tablespoons warm water


1. If using masa harina, place in a large, deep bowl and slowly add the water. Knead into a moist, cohesive dough that cleanly pulls away from the bowl and no longer feels sticky or thin, about 3 minutes. To test whether the masa is adequately hydrated, grab a piece, roll it into a ball, and flatten it. If the sides crack, the masa needs more water. The final texture should be slightly damp, like cold clay. Once the masa is ready, cover it with a damp dishcloth and let rest 15 minutes, which will result in a softer, more pliable dough.

2. If using fresh tortilla masa, sprinkle a little water, a tablespoon at a time, onto the masa and knead firmly until soft and pliable. You should need 1/4 cup water at the most, depending on how dry and crumbly the masa is.

3. Heat a comal or nonstick skillet to medium-low heat.

4. Break off a knob of masa and roll it into a smooth ball, about the size of a golf ball. Cover the rest of the dough with a damp dishcloth.

5. Flatten the dough ball between your palms, so it’s about 1/2 inch thick. Place on one side of a tortilla press lined with square sheets of plastic (these can be cut from plain grocery bags but avoid those with lettering or illustration as the coloring could leach onto the tortillas). Make sure the dough circle sits smoothly between the plastic sheets, then close the press. Push down the lever. 

6. Open the press and rotate the tortilla a quarter-turn, keeping the sheets intact. Close and push down on the lever again. Continue to rotate the tortilla until it’s evenly pressed into a round about 1/8-inch thick. (If you have a heavy press that will make a thin, even tortilla every time, you can skip the rotating routine.)

7. Open the tortilla press and peel back the top plastic sheet. Place the tortilla face down in your open palm, so about half of it sits in the center of your hand, the other half hanging off. Gently peel back the remaining plastic sheet. The dough should not stick to the plastic or your hands. If it does, you’ve added too much water and need to start over. 

8. Thicker tortillas will be easy to place on the comal. Tortillas made with fresh masa, however, take some practice. With half the tortilla resting in your open palm, and the other half hanging off the side, stand over the comal and slowly move your hand in a horizontal fashion, spreading the tortilla so the underside hits the comal first.

9. Flip—with a heatproof spatula or your callused fingers— as soon as the outer edges of the tortilla start to darken and look less moist, about 45 seconds. The tortilla should have some dark-brown freckles at this point. If it doesn’t, raise the heat. Alternately, if it’s blackened, lower the heat.

10. Flip the tortilla again as soon as small air bubbles start to appear on the freckled surface, about 35 seconds. At this point, after the second flip, the tortilla might inflate. Cook the tortilla for another 25 seconds, and then push it to the side of the comal, away from hot direct heat, and cook 25 seconds more. Flip once more and cook for another 45 seconds, for a total of roughly 3 minutes per tortilla, depending on how hot your stove is. Place the tortilla in a dishcloth or covered basket to keep warm.

11. Repeat steps 3 through 10. Serve the tortillas warm and store any leftovers in an airtight container in the refrigerator for up to a week, or alternately, freeze for longer storage. To reheat, place thawed tortillas on a comal, or reheat individually on a gas burner.

Cooking Tip: Cal, the Spanish word for calcium oxide, is an alkaline solution needed for nixtamalizing corn. In Mexico you can occasionally find it in rock form, but in the U.S. it’s generally white  and powdery, and available in small packets at Mexican grocers.

Fresh Nixtamal

This makes quite a bit of masa—around 3 pounds—but if making fresh nixtamal is new for you, you’ll want to have some leftover dough for use later. I prefer to freeze extra dough in 1-pound balls, in sealed plastic bags, or, if I have a friend on hand to help, we’ll make tortillas or tlacoyos and freeze those. Masa or frozen tortillas should last at least a few months in the freezer, tightly sealed.

2 pounds dried corn for making tortillas/masa
3 quarts cold water
1 tablespoon plus 1 teaspoon powdered calcium oxide, also known as cal

1. Pick over the corn carefully, removing any stones or bits of matter.

2. Pour the water into a large pot. Add the calcium oxide and stir until dissolved. Bring this mixture to a vigorous boil.

3. Stir in the corn, making sure it does not stick to the bottom. Lower the flame to medium, and simmer until the outer skin of the corn barely scrapes off with your fingernail, 7 to 10 minutes. The corn will still be hard at this point. Do not overcook it or else your masa will be too gummy.

4. Remove the pot from the heat and cover. Let sit at least 6 hours or overnight.

5. The next day, drain the corn. Wash the kernels well, rubbing them between your hands to loosen and discard any errant skins. This may take 5 to 10 minutes, depending on how many of the skins came loose in the pot.

6. At this point the corn is ready to be ground, either by hand or at a local mill. (The kernels must be cool or room temperature in order to do so.) Once the corn has been ground into tortilla masa, it must be sufficiently hydrated and kneaded (see “Troubleshooting Homemade Corn Tortillas” opposite for detailed instructions). Then the masa is ready to be shaped into tortillas.

Excerpted from Eat Mexico by Lesley Téllez. Published by Kyle Books. Photography by Penny De Los Santos.


  • mesa (fresh tortillas)